Product ID:9299 ETHYLENEDIAMINE
MSDS Date:03/09/1992
FSC:6810
NIIN:00F034173
MSDS Number: BTNCD

J T BAKER INC

222 RED SCHOOL LANE
PHILLIPSBURG, NJ 08865-2219
US

Emergency Phone: 908-859-2151

Info Phone: 908-859-2151

Cage: DO803

MALLINCKRODT BAKER, INC.

PHILLIPSBURG, NJ 08865 US

Telephone: 800-582-2537

Cage: 70829

1,2-DIAMINOETHANE, ETHYLENEDIAMINE

CAS: 107-15-3

RTECS: KH8575000

Fraction By Weight: 90-100%

OSHA PEL 25 MG/CUM

ACGIH TLV: 25 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

LD50 LC50 Mixture:ORAL LD50 (RAT): 1160 MG/KG SEE SUPP
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION MUCOUS
MEMBRANE. SKIN: IRRITATION/BURNS/RAPID ABSORPTION/SENSITIZATION.
EYES: IRRITATION/BURNS. INGESTION: GI IRRITATION/BURNS TO MOUTH &
THROAT. KIDNEY/LIVER DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:HEADACHE, NAUSEA, VOMITING, DIZZINESS, BURNS &
IRRITATION.

First Aid:INGESTION: DON'T INDUCE VOMITING. IF CONSCIOUS, GIVE
WATER/MILK/MILK OF MAGNESIA. INHALATION: REMOVE TO FRESH AIR/GIVE
OXYGEN/CPR IF NECESSARY. EYES/SKIN: IMMEDIATELY FLUSH W/WATER FOR
15 MIN.

Flash Point Method:CC
Flash Point:33C/93F
Lower Limits:4.2
Upper Limits:14.4
Extinguishing Media:WATER SPRAY, ALCOHOL FOAM, DRY CHEMICAL/CO2
Fire Fighting Procedures:WEAR PROPER PROTECTIVE EQUIPMENT/SCBA W/FULL
FACE PIECE OPERATED IN POSITIVE PRESSURE MODE. MOVE CONTAINERS
W/OUT RISK. USE WATER TO KEEP CONTAINERS COOL.
Unusual Fire/Explosion Hazard:VAPORS MAY FLOW TO IGNITION SOURCES/FLASH
BACK. CLOSED CONTAINERS MAY EXPLODE. CONTACT W/STRONG OXIDIZERS MAY
CAUSE FIRE. AUTOIGNITION TEMP. 725F/384C.

Spill Release Procedures:WEAR SCBA/PROTECTIVE CLOTHING. SHUT OFF
IGNITION SOURCES, NO FLARES, SMOKING/FLAMES. STOP LEAK IF POSSIBLE
W/OUT RISK. USE WATER SPRAY. TAKE UP W/SAND/COMBUSTIBLE ABSORBENT
MATERIAL & PLACE INTO CONTA INER. FLUSH AREA W/WATER.

Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. STORE
IN A COOL, DRY WELL-VENTILATED, FLAMMABLE LIQUID STORAGE AREA.
FLAMMABLE.
Other Precautions:BOND & GROUND CONTAINERS WHEN TRANSFERRING LIQUID.
PRODUCT MAY SOLIDIFY AT ROOM TEMP. AVOID CONTACT
W/EYES/SKIN/CLOTHING & BREATHING VAPORS.

Respiratory Protection:AT CONCENTRATION UP TO 500 PPM, USE A CHEMICAL
CARTRIDGE W/AMMONIA/AMINE CARTRIDGE. >500, USE SCBA.
Ventilation:GENERAL/LOCAL EXHAUST, VENT HOOD
Protective Gloves:BUTYL RUBBER
Eye Protection:SAFETY GOGGLES/FACE SHIELD
Other Protective Equipment:UNIFORM, PROTECTIVE SUIT, LAB COAT, APRON
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
HEALTH DATA: LD50 IS FOR ETHYLENEDIAMINE.

Boiling Pt:B.P. Text:242F/117C
Melt/Freeze Pt:M.P/F.P Text:51F/11C
Vapor Pres:10
Vapor Density:2.07
Spec Gravity:0.90
Evaporation Rate & Reference:(BU AC=1): 0.91
Solubility in Water:COMPLETE
Appearance and Odor:COLORLESS LIQUID W/AMMONIA ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, OXIDIZING AGENTS, HALOGEN ACIDS & COMPOUNDS, COPPER,
COPPER ALLOYS, COPPER SALTS.
Stability Condition to Avoid:HEAT, FLAME, OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:OXIDES OF NITROGEN, CO, CO2

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE &
FEDERAL REGULATIONS. EPA WASTE # D001, D002. CORROSIVE, FLAMMABLE
LIQUID UN1604

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.